Consett · County Durham
Roof structure repairs in Consett
Many older roofs, in Consett and across County Durham alike, were built with slim purlins and few ties. A little historic movement is normal, so we check whether the roof is still moving before recommending how far the strengthening needs to go.
Guide price from£275per rafter inc VAT
- Postcodes
- DH8
- Population
- about 29,000
- Area
- County Durham
- Pricing region
- North East
What should you know about the ground under Consett?
Consett (DH8) has around 29,000 residents and sits in County Durham. Nearby places we cover include Stanley (5 miles), Whickham (9 miles) and Blaydon-on-Tyne (9 miles).
Clay soils are found in parts of County Durham. Historic coal workings are recorded beneath parts of County Durham, and a coal mining search is worth checking where movement is unexplained. Typical buildings in County Durham: Colliery terraces, stone and brick villas in Durham and Darlington, and post-war council estates.
What to look for before calling about roof structure repairs
- Roof slope looking hollow or wavy between the ridge and the gutter
- Horizontal cracks in the wall just below the eaves or ceiling line
- Top of an outside wall leaning out at eaves level
Roof structure repairs prices in Consett
For Consett we use North East rates. Treat the table as a budget guide, inc VAT; the price you pay is the one on your written quote.
| Item | Guide price | Per |
|---|---|---|
| Repairing or doubling a rafter | £275 – £550 | per rafter |
| Purlin and strut strengthening | £1,100 – £2,750 | per roof |
| Tying in roof spread (straps and ties)est. | £735 – £2,300 | per roof |
How we usually approach roof structure repairs
Wall plate replacement
Rotten or crushed wall plates are replaced in short lengths while the rafters above are propped, and bedded on the wall in mortar. The plate is then strapped down to the masonry. It is often combined with rafter foot splices along the same run.
Best for: Rot along the eaves where rafters bear on the wall
Purlin and strut strengthening
Undersized purlins are strengthened with extra timber or replaced, and new struts are taken down to a load-bearing wall. Where there is no suitable wall, an engineer designs the load path. Temporary props hold the roof while members are changed.
Best for: Sagging slopes, slim purlins and struts removed from the loft
What happens during roof structure repairs, step by step?
Send photos
Photograph the roof from across the street, both slopes if you can, and the loft timbers with a torch. Include the eaves and any cracks just below them. From these we can usually tell sag from spread and whether an engineer is needed.
Engineer’s design where needed
Where purlins, struts or ties must be redesigned, or the roof carries a heavier covering, an independent chartered structural engineer is appointed to specify the work. We can arrange this, and their design sets the sizes and fixings.
Written quote
You receive a no-obligation written quote listing each timber repair, any ties or straps, propping, scaffolding and making good. Once the repair is specified, the figure becomes a fixed price in writing.
Rules for roof structure repairs in England
In England, underpinning and other work that alters or strengthens a wall or foundation is building work under the Building Regulations (Part A, structure), so building control approves and inspects it. Like-for-like repairs often are not, and we tell you which applies before a price is agreed. Work to a party wall, or excavation close to a neighbour’s foundations, can also need a notice under the Party Wall etc. Act 1996.
Questions about roof structure repairs in Consett
How much will roof structure repairs cost in Consett?
Guide prices for roof structure repairs in Consett start from about £275 per rafter, including VAT, on North East rates. Your fixed written price follows photos or a survey and depends on the extent of the work and access.
Do you cover Consett?
Yes. We take enquiries from across Consett, including DH8, and from nearby places such as Stanley and Whickham. Send photos for a free initial view and we will tell you what happens next.
Is the ground in County Durham prone to subsidence?
Much of County Durham sits on the Durham Coalfield, worked for centuries, often under a cover of glacial clay. Many former pit villages have recorded mine workings, and coal mining searches are standard for property here. Only an investigation can say why a particular building has moved.
Why are there cracks just below the eaves?
A horizontal crack just below the eaves, along the front or back wall, is a common sign of roof spread. The rafters push the top of the wall outward and the masonry cracks where it hinges. Corroded wall ties can cause similar cracks, so the cause needs checking.
Can heavy concrete tiles damage a roof?
Yes, if the frame was designed for lighter slate or tiles and was not strengthened. The extra weight makes rafters and purlins sag and can bring on roof spread. Before re-roofing in a heavier material, have the structure checked and notify building control.
Other structural repairs in Consett
- Extension pulling away repairs
- Floor joist repairs
- Gable end wall repairs
- Bay window subsidence repairs
- Bowing wall repairs
Roof structure repairs near Consett
Every rafter, purlin and tie on the job in Consett is listed in the written quote, which becomes a fixed price in writing once the repair is specified.